Tutorials 1991-1994 240sx

Got questions about your Nissan? We're here to help, and it's FREE!
Posts: 3197
Joined: Thu Oct 30, 2003 1:30 am
Car: 1991 240sx

Tutorials 1991-1994 240sx

Postby vancouverbc » Tue May 29, 2007 2:20 pm

240sx articles organized by category
Non-240sx Nissan articles

1989-1998 240sx tutorials (91-94 unless indicated) :

AIV removal(PAIR valve)
Air Regulator
Alternator removal
Antenna Install
Automatic transmission-1991-1994-FSM
Battery terminal replacement
Battery FAQ
Bolt sizes
Brakes-Bleeder screw
Brakes-rear caliper/sliding pin
Brakes-replace rear pads
Brakes-replace rear rotors
Brake master cylinder replacement
Brake Pedal-switch/bushing
Brake light
Buying guide-1989-1998
Cam Alignment(1991-1998)
Cam Alignment-jim wolf 91-98
Catalytic converter
Cleaning Detailing
Clutch master cylinder
Clutch Pedal-switch/bushing
Clutch pedal-zilvia
Clutch-removing damper loop
Clutch-interlock relay/switch
Clutch Throwout bearing
Clutch and flywheel replacment pictures
Clutch-replacing (no pictures)
Codes: retrieving and reading(1991-1994)
Codes: retrieving & reading(1995-1998)
Codes: retieving & reading(1989-90 SOHC)
Code 34 detonation/knock sensor
Compression test methodology
Computer codes: reading
Consult- OBD 1
Control arm-front lower control arm replacement
Coolant system-general
Coolant change
Coolant-Temperature sensor
Crankshaft position sensor
Crankshaft- rear seal
Crankshaft-front and rear seals
CV boot replacement
Dash removal
Defogger-rear defroster(1989-1998)
Detonation sensor/knock sensor
Differential-aftermarket install
Differential oil change
Distributor see Timing
Distributor timing
Dist. timing trouble-shoot
Door-hinge sags Needs work
Door latch troubleshooting(Driver's door)
Door Panel removal
ECU-serial numbers
ECU- Tuning
EGR removal and cleaning
EGR pipe soldering repair
Electronic help
Emissions removal-DOHC good article
Emissions Removal-SOHC
Engine Removal 1991-98
Engine-Head Job
Engine Build-DOHC
Exhaust manifold removal
Factory service manual-1991-1994
Factory service manual 1989 best
Factory service manual-1989-1990
Factory service manual-1995
Factory service manual-1998
Fan Clutch
Fender brace install
Freeze plug(expansion)
Front seal replacement
Front and rear seals
Fuel filter replacement
Fuel injector Cleaning
Fuel injector replacement
Fuel Injector Leak test
Fuel pressure regulator
Fuel Pressure specs(see fuel pressure reg. article 34/43 psi)
Fuel pump install
Fuel Pump install(s14)
Fuel Pump -s14
Fuel pump Needs work
Fuel pump kill switch
Fuse & Relay Locations
Ground kit
Hatch-water leak
Hatch supports/lifts
Headlight troubleshooting
Headlight switch cleaning
Headlight motor replacement
Hub Removal
Idle-stalling at stop lights
Idle adjustment
IACV AAC cleaning & electrical trouble-shooting
Ignition lock/switch
Injector-See fuel
Ignitor testing
Intake manifold-DOHC good article
Intake manifold SOHC
Intake-AEM install on 1997
Intake manifold bracket removal
Interlock relay/switch
Knock sensor/Detonation sensor
Light bulb replacement-dash
Leak down test- FUEL
Light bulb- S14 Climate control
Master cylinder(brake) replacement
Master cylinder brake bleeder kit
Motor mount
Motor mount-homemade
Motor mount-homemade #2
Muffler- stock rear
Oil pump inspection-SOHC only
Oil Pump-DOHC
Oil Pan Removal
Oil pressure sensor
Oxygen sensor
Paint codes
PCV replacement
Power steering-hose replacement
Power steering-rebuild for 1995
Power steering pump-removal/replacement
Power steering system-bleeding
Power Transistor
Rear main seal
Rear main seal no pics, but more accurate
Seat upgrade
Seat belt Warranty
Seat Fitment guide
Speed Sensor
Stalling-at stop lights
Starting -hard start when engine warm
Starting-hard start when engine cold
Starter trouble-shooting-Engine won't turn over
Steering-also see power steering
Steering wheel removal
1990 steering rack replacement
Steering-rack bushing replacement
Steering-Tie rod removal
Steering-tie rod
Steering-tie rod/rack angle
Steering- s14 rack
Stereo Faq see radio
Stripped bolt remedy
Stripped bolt remedy #2
Stud replacement
Stud replacement #2
Subframe bushings
Subframe collar/spacer
Suspension: Front Struts
Suspension: Rear shocks
Suspensiion-Sway bar end link, Tension control rod, Control arm bushings(all front)
Suspension: front lower control arm replacement
Suspension-Rear ball joint
Suspension-Ball joint replacement video
Suspension-tension control rod
Suspension: Rear sway bar end link
Suspension: Front sway bar end link 14-22lbs torque
Temperature sensor-coolant
Time control unit
TPS replacement
Throttle position sensor(TPS)
Throttle body removal
Throwout bearing
Tie rod removal
Timing Light guide
Dist. timing trouble-shoot
Timing Chain Rattle(1991-1998)
Timing chain rattle(SOHC)(1989-90)
Timing chain install (SOHC)
Timing chain replacement(SOHC) best
Timing Chain (DOHC) Incomplete
Tire chains
Top Dead Center
Transmission seal
Tran mount
TPS- see throttle
Transmission oil change
Vacuum diagrams
Vacuum line pictures
Vacuum Pump Leak
Valve removal/seal replace
Water pump replacement
Water pump(1995-1998)
Wheel stud replacement
Wheel stud replacement2
Wheel Hub Removal
Wheel bearing replacement-rear
Windshield wiper noise fix
Window-repairing amp(1989-1995)
Window-repairing power windows(1996-1998)
Window-replace motor 1995-98
Window button repair-1995 only
Wiring diagrams

****CUSTOM INSTALLS************************************
Air intake install
Air Intake install-S14-(AEM)
Air Intake-Custom S14
Brake upgrade-240sx to 300zx
Clutch install
Fan-electric wiring
Fan-electric wiring
Fan install-electric for s14
Header Install
Hood pin install
LSD(limited slip differential) install
Nitrous oxide-direct port wet kit 1990 240sx
Painting-headlight housing
Sound system intall 1995 240sx
Suspension-coilover conversion
Swap-auto to 5speed s14
Turbo-1989 240sx
Turbo 1990 240sx

Note: People are just sharing their experience in these articles/tutorials. The authors are not experts. Always refer to factory service manual for safety and expert opinion.

IMPORTANT DISCLAIMER: Trusting your life to something you read on the internet is just plain stupid. Get corroboration from a more reliable source, use your common sense, don't get yourself killed, and don't come crying to us if you do

Posts: 3197
Joined: Thu Oct 30, 2003 1:30 am
Car: 1991 240sx

Re: (finallya240)

Postby vancouverbc » Sat Jan 17, 2009 5:07 pm

You dont have to download fsm as they are hosted by NICO here:


User avatar
Posts: 365
Joined: Sat Oct 10, 2009 7:00 pm
Car: 92 hatchback 240sx, j30 diff, TIEN tie-rods
Location: N. FLA

Re: Tutorials

Postby ShouldaHadaV8 » Sun May 02, 2010 6:00 pm

Somebody should make a tutorial for how to do for the EGR delete, and what to do with the remaining vacuum system.

Posts: 1
Joined: Fri Apr 30, 2010 9:57 pm
Car: 95/240SX/SE

Re: Tutorials

Postby richardKat » Tue May 04, 2010 7:05 pm

Thank you, I really needed this.

Return to “Nissan Online Mechanic”